All Issue

2026 Vol.38, Issue 2 Preview Page
Integrated Techno-Economic and Environmental Assessment of a Decentralized Biochar System Using Agricultural Residues
Sunyong Park1
,
DaeHyun Kim2
,
Kwang Cheol Oh3*
1Post-doctoral Research Associate, Forest Industrial Materials Division, National Institute of Forest Science 02455, Korea
2Professor, Department of Biosystems Engineering, Kangwon National University, Chuncheon 24341, Korea
3Senior Researcher, Korea Research Institute on Climate Change, Chuncheon 24239, Korea
*Corresponding Author
30 June 2026. pp. 151-170
PDF XML Citation
Abstract

This study presents an integrated techno-economic and environmental assessment of a decentralised 1 ton/day biochar production system using agricultural residues. A small-scale configuration including feedstock collection, pelletisation, and torrefaction was designed based on experimental data and literature-derived parameters. Capital expenditure was estimated using equipment scaling methods, and operating costs were calculated from market-based unit prices. Economic performance was evaluated through discounted cash-flow analysis and Monte Carlo simulation over a 20-year horizon. The capital structure was dominated by the torrefaction reactor and indirect installation costs, while operating expenditure was primarily driven by labour, followed by thermal and electricity demand. Under baseline assumptions, the project achieved a positive net present value and an internal rate of return exceeding the 5% discount rate, indicating moderate feasibility. However, scenario and probabilistic analyses revealed strong sensitivity to labour intensity and transportation costs. A cradle-to-gate life cycle assessment focusing on global warming potential was conducted using the Brightway2 framework. Off-gas energy recovery was incorporated into process heat demand to avoid carbon double counting. Although biogenic CO2 treatment significantly affected absolute GWP values, electricity and process heat consistently emerged as the dominant environmental hotspots. The integrated results indicate that economic performance is labour-driven, whereas environmental performance is governed by utility demand, highlighting complementary optimisation pathways for improving decentralised biochar sustainability.

Keywords
Biochar
Decentralised biomass system
Global warming potential
Life cycle assessment
Techno-economic analysis
References
1

Abdullah, H., Wu, H. (2009) Biochar as a fuel: 1. Properties and grindability of biochars produced from the pyrolysis of mallee wood under slow-heating conditions. Energy and Fuels 23:4174-4181.

10.1021/ef900494t
2

Bisset, V. (2023) The U.N. warns ‘an era of global boiling’ has started. What does that mean?. Washington Post.

3

Bridgeman, T. G., Jones, J. M., Shield, I., Williams, P. T. (2008) Torrefaction of reed canary grass, wheat straw and willow to enhance solid fuel qualities and combustion properties. Fuel 87:844-856.

10.1016/j.fuel.2007.05.041
4

Cardoso, J., Silva, V., Eusébio, D. (2019) Techno-economic analysis of a biomass gasification power plant dealing with forestry residues blends for electricity production in Portugal. J Clean Prod 212:741-753.

10.1016/j.jclepro.2018.12.054
5

Carvalho, J., Nascimento, L., Soares, M., Valério, N., Ribeiro, A., Faria, L., Silva, A., Pacheco, N., Araújo, J., Vilarinho, C. (2022) Life cycle assessment (LCA) of biochar production from a circular economy perspective. Processes 10:2684.

10.3390/pr10122684
6

Ceglia, F., Marrasso, E., Roselli, C., Sasso, M., Coletta, G., Pellegrino, L. (2022) Biomass-based renewable energy community: Economic analysis of a real case study. Energies (Basel) 15:5655.

10.3390/en15155655
7

Centre, E. (2023) Ecoinvent database version 3.9.

8

Colantoni, A., Villarini, M., Monarca, D., Carlini, M., Mosconi, E. M., Bocci, E., Rajabi Hamedani, S. (2021) Economic analysis and risk assessment of biomass gasification CHP systems of different sizes through Monte Carlo simulation. Energy Reports 7:1954-1961.

10.1016/j.egyr.2021.03.028
9

Davis, R., Olcay, H., Talmadge, M., Dempsey, J., Tao, L., Klein, B., Tan, E., Do, T. N., Ou, L., Cai, H. (2025) Technology case study: Economic, sustainability, and deployment considerations for sustainable aviation fuels produced via lignocellulosic sugar catalysis. National Renewable Energy Laboratory (NREL), Golden, Colorado, United States.

10

Davis, R., Tao, L., Tan, E. C. D., Biddy, M. J., Beckham, G. T., Scarlata, C., Jacobson, J., Cafferty, K., Ross, J., Lukas, J., Knorr, D., Schoen, P. (2013) Process design and economics for the conversion of lignocellulosic biomass to hydrocarbons: Dilute-acid and enzymatic deconstruction of biomass to sugars and biological conversion of sugars to hydrocarbons. NREL/TP-5100-60223, National Renewable Energy Laboratory (NREL), Golden, Colorado, United States.

10.2172/1107470
11

Ennis, C. J., Evans, A. G., Islam, M., Ralebitso-Senior, T. K., Senior, E. (2012) Biochar: Carbon sequestration, land remediation, and impacts on soil microbiology. Crit Rev Environ Sci Technol 42:2311-2364.

10.1080/10643389.2011.574115
12

International Organization for Standardization (2020) ISO 14044:2020 Environmental management — Life cycle assessment — Requirements and guidelines.

13

Jones, S. B., Snowden-Swan, L. J., Valkenburg, C. E. (2011) Techno-economic analysis of biomass fast pyrolysis to transportation fuels. NREL/TP-6A20-46586, Renewable Energy Laboratory (NREL), Golden, Colorado, United States.

14

Kalinci, Y., Hepbasli, A., Dincer, I. (2009) Biomass-based hydrogen production: A review and analysis. Int J Hydrogen Energy 34:8799-8817.

10.1016/j.ijhydene.2009.08.078
15

Kang, Y., Yoo, Y., Kang, G., Kim, Y., Baek, Y., Kim, J., Kim, Y., Jang, J., Lee, H., Lee, S. (2010) Development of treatment and energy utilization technology for agricultural and forestry by-products. Rural Development Administration, Jeonju, Korea.

16

Karaosmanoǧlu, F., Işigigür-Ergüdenler, A., Sever, A. (2000) Biochar from the straw-stalk of rapeseed plant. Energy and Fuels 14:336-339.

10.1021/ef9901138
17

Keil, R. G., Nuwer, J. M., Strand, S. E. (2010) Burial of agricultural byproducts in the deep sea as a form of carbon sequestration: A preliminary experiment. Mar Chem 122:91-95.

10.1016/j.marchem.2010.07.007
18

Kim, D., Kim, S., Kim, S., Song, Y. (2024) Development of mobile surface torrefaction plant for wood pellet and wood chips from unused forest biomass. Kangwon National University Industry-Academic Cooperation Foundation, Chuncheon, Korea.

19

Kim, S.-B., Ha, J.-W. (2019) A study on the characteristics of coffee ground (CG)-RDF by using different drying method. JKAIS 20:451-457.

20

Klein, B., McNamara, I., Davis, R., Mittal, A., Johnson, D. (2021) Techno-economic assessment for the production of hydrocarbon fuels via catalytic upgrading of furans. NREL/TP-5100-80652, Renewable Energy Laboratory (NREL), Golden, Colorado, United States.

10.2172/1819430
21

Kourmentza, C., Economou, C. N., Tsafrakidou, P., Kornaros, M. (2018) Spent coffee grounds make much more than waste: Exploring recent advances and future exploitation strategies for the valorization of an emerging food waste stream. J Clean Prod 172:980-992.

10.1016/j.jclepro.2017.10.088
22

Lee, C. G., Lee, S. Y., Joo, S. Y., Cho, L. H., Park, S. Y., Lee, S. H., Oh, K. C., Kim, D. H. (2017) A study on agricultural by-products for biomass-to-energy conversion and Korean collecting model. New Renew Energy 13:27-35.

10.7849/ksnre.2017.3.13.1.027
23

Lee, K. T., Shih, Y. T., Rajendran, S., Park, Y. K., Chen, W. H. (2023a) Spent coffee ground torrefaction for waste remediation and valorization. Environ Pollut 324:121330.

10.1016/j.envpol.2023.121330
24

Lee, Y. G., Cho, E. J., Maskey, S., Nguyen, D. T., Bae, H. J. (2023b) Value-added products from coffee waste: A review. Molecules 28:3562.

10.3390/molecules2808356237110796PMC10146170
25

Lehmann, J., Joseph, S. (2009) Biochar for environmental management science, technology (2nd ed). Routledge, Routledge, England.

26

Lionello, P., Scarascia, L. (2018) The relation between climate change in the Mediterranean region and global warming. Reg Environ Change 18:1481-1493.

10.1007/s10113-018-1290-1
27

Maroušek, J., Trakal, L. (2022) Techno-economic analysis reveals the untapped potential of wood biochar. Chemosphere 291:133000.

10.1016/j.chemosphere.2021.133000
28

McCarthy, M. P., Best, M. J., Betts, R. A. (2010) Climate change in cities due to global warming and urban effects. Geophys Res Lett 37:L09705.

10.1029/2010GL042845
29

McNulty, M. J., Kelada, K., Paul, D., Nandi, S., McDonald, K. A. (2021) Introducing uncertainty quantification to techno-economic models of manufacturing field-grown plant-made products. Food Bioprod Process 128:153-165.

10.1016/j.fbp.2021.04.013
30

Muñoz Velasco, P., Mendívil, M. A., Morales, M. P., Muñoz, L. (2016) Eco-fired clay bricks made by adding spent coffee grounds: a sustainable way to improve buildings insulation. Mater Struct 49:641-650.

10.1617/s11527-015-0525-6
31

Mutel, C. L. (2017) Brightway2: Open source framework for life cycle assessment. J Open Source Softw 2:236.

10.21105/joss.00236
32

Nam, G., Kim, M., Ahn, J. W. (2017) Analyses for current research status for the coffee by-product and for status of coffee wastes in Seoul. J Energy Eng 26:14-22.

10.5855/ENERGY.2017.26.4.014
33

Park, J. H., Ok, Y. S., Kim, S. H., Kang, S. W., Cho, J. S., Heo, J. S., Delaune, R. D., Seo, D. C. (2015) Characteristics of biochars derived from fruit tree pruning wastes and their effects on lead adsorption. J Korean Soc Appl Biol Chem 58:751-760.

10.1007/s13765-015-0103-1
34

Park, S., Jeong, H. R., Shin, Y. A., Kim, S. J., Ju, Y. M., Oh, K. C., Cho, L. H., Kim, D. (2021) Performance optimisation of fuel pellets comprising pepper stem and coffee grounds through mixing ratios and torrefaction. Energies (Basel) 14:4667.

10.3390/en14154667
35

Park, S., Kim, S. J., Cho, A. Y., Kim, Y., Lee, D. H., Oh, K. C., Jang, C. S., Kim, D. H. (2022) Effect of agro-byproduct biochar fertilization on cherry tomato growth and carbon sequestration. J Agric Life Environ. Sci 34:229-237.

10.22698/JALES.20220023
36

Park, S., Kim, S. J., Kim, H. E., Kim, S. Y., Oh, K. C., Cho, .L, Jeon, Y. K., Kim, D. H. (2024) Potential of torrefied coffee grounds to be used as fuel in thermal power plants. J Biosyst Eng 49:112-119.

10.1007/s42853-024-00220-5
37

Park, S., Kim, S. J., Oh, K. C., Cho, L., Kim, M. J., Jeong, I. S., Lee, C. G., Kim, D. H. (2020) Investigation of agro-byproduct pellet properties and improvement in pellet quality through mixing. Energy 190:116380.

10.1016/j.energy.2019.116380
38

Park, S., Kim, S. J., Oh, K. C., Jeon, Y. K., Kim, Y., Cho, A. Y., Lee, D., Jang, C. S., Kim, D. H. (2023) Biochar from agro-byproducts for use as a soil amendment and solid biofuel. J Biosyst Eng 48:93-103.

10.1007/s42853-023-00175-z
39

Park, S., Lee, S., Joo, S., Cho, L., Oh, K., Lee, S., Jeong, I., Lee, C., Hong, S., Kim, S., Kim, D. H. (2017) Simulation & model validation of torrefaction process and analysis of the fuel properties for pepper stem. New. Renew Energy 13:64-70.

10.7849/ksnre.2017.12.13.4.064
40

Solarte-Toro, J. C., Rueda-Duran, C. A., Ortiz-Sanchez, M., Cardona Alzate, C. A. (2021) A comprehensive review on the economic assessment of biorefineries: The first step towards sustainable biomass conversion. Bioresour Technol Rep 15:100776.

10.1016/j.biteb.2021.100776
41

Stulpinaite, U., Tilvikiene, V., Zvicevicius, E. (2023) Co-pelletization of hemp residues and agricultural biomass: effect on pellet quality and stability. Energies (Basel) 16:5900.

10.3390/en16165900
42

Turton, R., Bailie, R. C., Whiting, W. B., Shaeiwitz, J. A. (2008) Analysis, synthesis and design of chemical processes. pp.15-42. Pearson Education, England.

43

Waqas, M., Aburiazaiza, A. S., Miandad, R., Rehan, M., Barakat, M. A., Nizami, A. S. (2018) Development of biochar as fuel and catalyst in energy recovery technologies. J Clean Prod 188:477-488.

10.1016/j.jclepro.2018.04.017
44

Yang, I., Ahn, B. J., Kim, M.-Y., Oh, S. C., Ahn, S. H., Choi, I.-G., Kim, Y.-H., Han, G.-S. (2014) Separation of reducing sugars from rape stalk by acid hydrolysis and fabrication of fuel pellets from its residues. Korean J Plant Res 27:60-71.

10.7732/kjpr.2014.27.1.060
45

Yang, I., Han, G. S., Oh, S. W. (2018) Larch pellets fabricated with coffee waste and the commercializing potential of the pellets. J Korean Wood Sci Technol 46:48-59.

10.5658/WOOD.2018.46.1.48
46

Zhu, X., Labianca, C., He, M., Luo, Z., Wu, C., You, S., Tsang, D. C. W. (2022) Life-cycle assessment of pyrolysis processes for sustainable production of biochar from agro-residues. Bioresour Technol 360:127601.

10.1016/j.biortech.2022.127601
Information
  • Publisher :Agriculture and Life Sciences Research Institute, Kangwon National University
  • Publisher(Ko) :None
  • Journal Title :Journal of Agricultural, Life and Environmental Sciences
  • Volume : 38
  • No :2
  • Pages :151-170
  • Received Date : 2026-02-24
  • Revised Date : 2026-04-03
  • Accepted Date : 2026-04-13
  • DOI :https://doi.org/10.22698/jales.20260011
Journal Informaiton Journal of Agricultural, Life and Environmental Sciences Journal of Agricultural, Life and Environmental Sciences
Online Submission & Review System
  • NRF
  • KOFST
  • KISTI Current Status
  • KISTI Cited-by
  • KCI 문헌 유사도 검사_영문_불교학연구
  • orcid
  • open access
  • ccl
Journal Informaiton Journal Informaiton - close